The following list of auto parts that are often replaced is based on frequency (most often to least often), and are based on the average wear a typical vehicle owner should experience under normal driving conditions. It doesn’t mean the parts on your car will necessarily have to be replaced at the following time or mileage intervals, but it can give you an idea of what to expect down the road as your vehicle accumulates mileage and wear
1. Oil and Oil Filter – Every three to six months, or every 3,000 to 5,000 miles
2. Windshield Wiper Blades – Every year or two (less in hot climates if a vehicle sits outside and is exposed to sunlight and high ambient temperatures).
3. Air filter – Every three or four years, or 30,000 to 50,000 miles. Filter life can be much less if a vehicle is driven on dusty gravel roads.
4. Brake Pads – Every three to five years, or 30,000 to 70,000 miles. Replacement frequency can vary greatly depending on the type of vehicle (larger, heavier vehicles wear out their brake pads more quickly than smaller vehicles), the type of original equipment brake linings (semi-metallic and ceramic linings usually last much longer than no asbestos organic linings), the type of driving you do (stop-and-go city driving increases pad wear dramatically), and your driving style.
5. Battery – Every four to five years (mileage doesn’t matter). Less in really hot climates (maybe only three years).
6. Headlights and/or taillight bulbs – Five to seven years, depends on how much nighttime driving you do. Driving on rough, bumpy roads can also shorten the life of conventional bulbs with filaments (no effect on Xenon bulbs which do not have a filament inside, or LED taillights).
7. Tires – Every five to seven years, depending on number of miles driven annually, the type of driving you do, and the wear rating on the tires (a higher wear rating number means the tire should last longer). Hard cornering and aggressive driving can increase tire wear dramatically. So can wheel misalignment.
8. Spark Plugs – Platinum and iridium plugs should normally last 100,000 miles, or about 8 years if you drive 12,000 miles/year. Spark plugs may have to be replaced sooner if short trip driving causes them to foul, or your engine is burning oil due to worn rings or valve guide seals.
9. Belts – The serpentine belt should last 75,000 miles or about six years, and the timing belt (if your engine has one) should last 100,000 miles or about 8 years.
10. Brake Calipers, Wheel Cylinders and Master Cylinder – Typically last 100,000 miles or more, but eventually succumb to internal corrosion and deterioration of the rubber seals. Need to be replaced is leaking or sticking. Often replaced at second brake job (seldom necessary at first brake job).
11. Alternator – May last the life of your vehicle, or it may fail after 5 or 6 years of driving. The alternator keeps the battery charged, and supplies voltage for your vehicle’s electrical system. High demand applications typically shorten alternator life. Alternators are a frequently replaced item, and also a frequently misdiagnosed car part. Charging problems can often result from poor electrical connections (battery cables or alternator wiring harness). An alternator should always be tested BEFORE it is replaced to determine if it is good or bad.
12. Fuel Pump – May last the life of your vehicle, or it may fail after 5 or 6 years of driving. The fuel pump runs constantly, and can be damage by rust or dirt inside the fuel tank. Running the fuel tank dry or driving with a very low fuel level inside the tank may starve the pump for lubrication, causing it to fail. Fuel pumps are also a frequently replaced item, and also a frequently misdiagnosed car part. Fuel delivery problems are often caused by plugged fuel filters, bad fuel pressure regulators, or wiring or electrical problems.
13. Water pump – May last the life of your vehicle, or it may fail after 6 to 8 years of driving. The shaft seal inside the water pump wears, and eventually starts to leak. The loss of coolant will cause your engine to overheat.
14. Fuses – You may never have to replace a fuse on your vehicle, but fuses are a frequently replaced item because of electrical problems. Fuses protect against current overloads, so if a fuse has failed the circuit or component that the fuse protects may have a short or overload. Replacement fuses MUST be the SAME AMP RATING as the original fuse. Never substitute a fuse with a higher amp rating as this may increase the risk of a car fire!
15. Engine Sensors – Most sensors should last upwards of 150,000 miles, but accumulated time and mileage can cause some sensors to fail much sooner. A bad sensor will usually turn on the Check Engine Light and set a fault code. Oxygen sensors on late model cars should usually last upwards of 100,000 miles, but may be fouled at any mileage by coolant leaks or an engine that is burning oil. Throttle position sensors can develop worn spots causing erratic readings. Crankshaft Position Sensors can develop internal cracks or shorts from exposure to engine heat that affect their output. Same for coolant sensors. Mass airflow sensors may become contaminated with dirt or fuel varnish.
16. Muffler – Most late model original equipment mufflers are stainless steel, and will typically last 10 years or 100,000 miles (or more) depending on environmental exposure to road salt and moisture.
17. Shocks & Struts – The shocks and struts on many vehicles are NEVER replaced during the life of the vehicle. But after 50,000 to 75,000 miles of driving, many shocks and struts are getting noticeably soft. Replacing these parts is often recommended to restore like-new ride and handling. Shocks and struts may also be replaced at any time to upgrade performance handling.
18. Clutch – Varies greatly with how the vehicle is driven, but normally should last up to 100,000 miles with normal driving. Towing, aggressive driving and poor driving habits (such as “riding the clutch”) can drastically shorten the life of this component.
19. Automatic Transmission – Should last the life of your vehicle, but may fail at any point from 70,000 miles on. Towing, aggressive driving or anything that causes the transmission to run hotter than normal can shorten its life and lead to failure.